选型注意事项

  S7-300PLC的选型原则是据生产工艺所需的功能和容量进行选型，并考虑维护的方便性、备件的通用性，以及是否易于扩展和有无特殊功能等要求。选型时具体注意以下几方面：

  (1)有关参数确定。一是输入/输出点数(I/O点数)确定。这是确定PLC规模的一个重要依据，一定要根据实际情况留出适当余量和扩展余地。二是PLC存储容量确定。注意当系统有模拟量信号存在或要进行大量数据处理时，其存储容量应选大一些。

  (2)系统软硬件选择。一是扩展方式选择，S7-300PLC有多种扩展方式，实际选用时，可通过控制系统接口模块扩展机架、Profibus-DP现场总线、通信模块、运程I/O及PLC子站等多种方式来扩展PLC或预留扩展口;二是PLC的联网，包括PLC与计算机联网和PLC之间相互联网两种方式。因S7-300PLC的工业通信网络淡化了PLC与DCS的界限，联网的解决方案很多，用户可根据企业的要求选用;三是CPU的选择，CPU的选型是合理配置系统资源的关键，选择时必须根据控制系统对CPU的要求(包括系统集成功能、程序块数量限制、各种位资源、MPI接口能力、是否有

  PROFIBUS-DP主从接口、RAM容量、温度范围等)，并好在西门子公司的技术支持下进行，以获得合理的选型;四是编程软件的选择，这主要考虑对CPU的支持状况，我们的体会是：STEP7V4.0对有些型号的CPU不支持，硬件组态时会发生故障出错，而STEP7V5.0则不存在这种问题。

  二、设计及使用注意事项

  1. 设计注意事项

  设计时主要应注意以下几方面：

  (1)PLC输出电路中没有保护，因此在外部电路中应设置串联熔断器等保护装置，以防止负载短路造成PLC损坏。熔断器容量一般为0.5A。

  (2)PLC存在I/O响应延迟问题，因此在快速响应设备中应加以注意。MPI通信协议虽简单易行，但响应速度较慢。

  (3)编制控制程序时，好用模块式结构程序。这样既可增强程序的可读性，方便调试和维护工作;又能使数据库结构统一，方便WinCC组态时变量标签的统一编制和设备状态的统一显示。

  (4)硬件资源。要合理配置硬件资源，以提高系统可靠性。如PLC电源配电系统要配备冗余的UPS不间断电源，以排除停电对全线运行的不利影响。又如对电机的控制回路要进行继电器隔离，以消除外部负载对I/O模块的可能损坏。另外，系统设备要采用独立的接地系统，以减少杂波干扰。

PC New Honeywell R7861 A 1026 Self Check Ultraviolet Flame Amplifier In Box
1 PC New Honeywell Voyager 1400G 2D Area-Imaging Scanner
1 PC Used Honeywell 621-9939-C Link Module for Series 9000 In Good Condition
1 PC Used Honeywell XCL5010 Controller Module In Good Condition
1 pcs  Honeywell  L404F1102 pressure controller
1 pcs  HONEYWELL  LSXA3K-1A Limit switch
1 pcs  HONEYWELL CP-WM-VAV control panel
1 PCS  Honeywell HC900 DCS 900P01-0001 Tested
1 pcs HONEYWEL BXA3K-1A Explosion-proof limit switch
1 pcs honeywell  129464N  Ultraviolet phototube
1 pcs honeywell  R7861A1026 Protection relay
1 pcs honeywell  V5011P1038
1 pcs honeywell 129464N Ultraviolet phototube
1 pcs honeywell C7035A1023  Flame Sensor
1 pcs honeywell C7035A1023 Flame Sensor
1 pcs HONEYWELL CP-WM-VAV control panel
1 PCS Honeywell HC900 DCS 900C53-0001 Module Tested
1 PCS Honeywell HC900 DCS 900G02-0001 in good condition
1 PCS Honeywell HC900 DCS 900P01-0001 Tested
1 pcs Honeywell L404F1102 pressure controller
1 pcs HONEYWELL LSXA3K-1A Limit switch
1 pcs honeywell R7849A1023
1 pcs honeywell R7861A1026 Protection relay
1 pcs honeywell TBC1800A1011
1 pcs honeywell V5011P1038
1 PCS NEW Honeywell Pressure Switch SN3-280-LED
1 PCS New IN BOX Honeywell Air Valve Actuator D20010 D20010
1 PCS NEW IN BOX Honeywell Flame Monitor R4343D1017
1 product rating- 1 PC New Honeywell R7861 A 1026 Self Check Ultraviolet Flame Amplifier In Box
1 product rating- 1 pcs Honeywell L404F1102 pressure controller
1 product rating- 100% Tested Honeywell 5010 XC5010C 60-Day Warranty [1ix]
1 product rating- 1PC Brand New Honeywell R7861A1026 Burner Controller DHL free shipping
1 product rating- 1PC New Brand Honeywell R7861 A 1026 One year warranty R7861A1026 Fast Delivery
1 product rating- 1PC New Honeywell 3310G scanning platb fixed barcode scanner free shipping
1 product rating- 1PC New Honeywell L404F1094
1 product rating- 1PC New Honeywell R7861 A 1026 Self Check Ultraviolet Flame Amplifier R7861A102
1 product rating- 1PC New Honeywell R7861A1026 Burner Controller 1 year warranty
1 product rating- 1PC New Honeywell R7861A1026 Burner Controller 1 year warranty#XR
1 product rating- 1PC New Honeywell R7861A1026 Burner Controller one year warranty fast delivery
1 product rating- 1PC New Honeywell R7861A1026 Burner Controller one year warranty free shipping
1 product rating- 1PC New Honeywell RF receiver module spare parts W8665E1000 1 year warranty#XR
1 product rating- 1PC New in box Honeywell R7861 A 1026 One year warranty R7861A1026 Fast Delivery
1 product rating- 1PC New LSN1A honeywell limit switch
1 product rating- 1pcs New Honeywell Pressure Controller L404F1102
1 product rating- Brand New Honeywell R7861A1026 Burner Controller DHL free shipping
1 product rating- EXCEL. HONEYWELL RM7838B1013 BURNER CONTROL R7861A1026,ST7800A1005,Q7800A1005,BV
1 product rating- Full Tested Honeywell 5010 XC5010C 60-Day Warranty [fkc]
1 product rating- HONEYWELL 113228 / 113228 (NEW IN BOX)
1 product rating- Honeywell 113228 Bulb
1 product rating- HONEYWELL 30756113-501 / 30756113501 (BRAND NEW)
1 product rating- HONEYWELL 3310G / 3310G (USED TESTED CLEANED)
1 product rating- HONEYWELL 3310G-4USB-0 / 3310G4USB0 (NEW IN BOX)
1 product rating- HONEYWELL 5495 / 5495 (USED TESTED CLEANED)
1 product rating- HONEYWELL 5881ENHC / 5881ENHC (NEW IN BOX)
1 product rating- HONEYWELL 620-0090 / 6200090 (USED TESTED CLEANED)
1 product rating- HONEYWELL 620-0090 ISSC IPC PLC MODULE CARD I/O RACK CHASSIS
1 product rating- HONEYWELL C7035A-1023 / C7035A1023 (BRAND NEW)
1 product rating- HONEYWELL FLAME SAFEGUARD RA890H1052 *USED*
1 product rating- HONEYWELL HM600XROF1 / HM600XROF1 (BRAND NEW)
1 product rating- HONEYWELL L4017B-1194 / L4017B1194 (USED TESTED CLEANED)
1 product rating- HONEYWELL L91B1035 / L91B1035 (BRAND NEW)
1 product rating- HONEYWELL L91B-1050 / L91B1050 (BRAND NEW)
1 product rating- HONEYWELL M8405A-1006 / M8405A1006 (BRAND NEW)
1 product rating- HONEYWELL M8405A1006 24V 3 POSITION DAMPER
1 product rating- Honeywell M8405a1006 Electric Actuator,25 In.-Lb.,24Vac
1 product rating- HONEYWELL M8405A1006 M8405A1006 24V 3 Position Damper
1 product rating- Honeywell M8405A1006/B 24 Vac Modulating Motor
1 product rating- Honeywell M9182A-1011 Modutrol IV Motor M9182A1011 Tested
1 product rating- HONEYWELL ML6174B-2019 / ML6174B2019 (BRAND NEW)
1 product rating- HONEYWELL MP953C1083 Mp953C1083 Valve Actuator
1 product rating- Honeywell MP953C1083 Valve Actuator
1 product rating- HONEYWELL MS4120A1209 / MS4120A1209 (BRAND NEW)
1 product rating- Honeywell MS4120A1209/U Honeywell Two Position Direct-Coupled Actuator
1 product rating- HONEYWELL MS4120F1006 Electric Actuator,-40 to 130F,SPST
1 product rating- HONEYWELL MS4120F1006, SPRING RETURN,TWO-POSITION 175 lb-in - FREE SHIPPING
1 product rating- Honeywell MS4120F1006/U Honeywell Fast-Acting, Actuator
1 product rating- HONEYWELL Q179A-1183 / Q179A1183 (BRAND NEW)
1 product rating- HONEYWELL R7847B-1031 / R7847B1031 (USED TESTED CLEANED)
1 product rating- Honeywell R7861A 1026 Industrial Control System NEW CIB - Free Shipping
1 product rating- HONEYWELL R7861A-1026 / R7861A1026 (USED TESTED CLEANED)
1 product rating- HONEYWELL RM7838 B 1013 ST7800A 1005,R7847C1005,dynamic Flame Burner ,HA
1 product rating- HONEYWELL RM7838 B 1013,ST7800A 1005,R7847 B 1031,dynamic Flame Burner ,SH
1 product rating- HONEYWELL RM7885A1015 BURNER CONTROL
1 product rating- Honeywell RM7890 B 1048 Primary Flame Safeguard Burner Boiler Control Relay
1 product rating- Honeywell RM7890 B 1048 Primary Flame Safeguard Burner Control Relay Module
1 product rating- HONEYWELL S87D1012 S87D1012 Dsi Control 11 Sec.
1 product rating- HONEYWELL S87K1008 / S87K1008 (BRAND NEW)
1 product rating- HONEYWELL SV9520H8513 / SV9520H8513 (BRAND NEW)
1 product rating- HONEYWELL T991A-1061 / T991A1061 (NEW IN BOX)
1 product rating- HONEYWELL UDC3000 TEMPERATURE CONTROLLER DC300K-E-0A0-21-0000-W
1 product rating- Honeywell V4055A1007 Low Pressure On/OFF Actuator Used on V5055/V5097A/B Valves
1 product rating- HONEYWELL V4943A1029 / V4943A1029 (BRAND NEW)
1 product rating- HONEYWELL V8944N-1012 / V8944N1012 (BRAND NEW)
1 product rating- Honeywell V8944N1012 Industrial Diaphragm Gas Valve
1 product rating- HONEYWELL Y8610-U-3003 / Y8610U3003 (NEW IN BOX)
1 product rating- Honeywell Y8610U6006 Electronic Retrofit Ignition System for LP or Natural Gas
1 product rating- NEW HONEYWELL MS4120F1006 DIRECT COUPLED ACTUATOR 2 POSITION
1 product rating- NEW IN BOX Honeywell R7861A1026 Burner Controller 1 year warranty
1 product rating- ONE USED Honeywell controllers PUL4024S USED
1 product rating- R7861A1026 Honeywell Burner Controller 1 Year Warranty New
1 product rating- S87D1012 Honeywell Dsi Module 11 Sec. Lockout OEM S87D1012
1 product rating- USED HONEYWELL BURNER CONTROL RM7823A1016,BOXZL
1 product rating- USED HONEYWELL M9182A-1011 MODUTROL IV MOTR M9182A1011
1 product rating- USED HONEYWELL RM7823 A 1016 BURNER CONTROL RM7823A1016
1 X CSNK591-001 CSNK591001 CSNK591 HONEYWELL CURRENT SENSOR NEW IN BOX
100% NEW Honeywell 113228 in box
100% NEW Honeywell 129464N in box
100% NEW Honeywell BC1000A0220U in box
100% NEW Honeywell BC1000A0220U/E in box
100% NEW Honeywell C7035A 1023 in box
100% NEW Honeywell H7080B3103 in box
100% NEW Honeywell H7080B3243 in box
100% NEW Honeywell L404F 1094 in box
100% NEW Honeywell L91B1050 in box
100% NEW Honeywell R7849 A 1023 in box
100% NEW Honeywell VE4010A1063 in box
100% NEW Honeywell VE4020A1195 in box
100% NEW Honeywell VE4025A1210 in box
100% NEW Honeywell VE4025A1210T in box
100% NEW Honeywell XFL523B in box
100% NEW pilz P2HZ X1 in box